Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 HOPPY PIG, INC. 		License/Permit #
 BR334
Street Address
135 N KINZIE AVE
City/State
 BRADLEY, IL 		ZIP Code
 60915
No. of Risk Factor/Intervention Violations 1
No. of Repeat Risk Factor/Intervention Violations 0
Date 02/25/2025
Time In 09:45 AM
Time Out 10:35 AM
Permit Holder
SPELLMAN, KAREN 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible X  

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39 X Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43 X In-use utensils: properly stored   X
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45 X Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47 X Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean   X

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55   Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58   Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: HOPPY PIG, INC. Establishment #: BR334
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: QUAT 200/CHLORINE 100 Heat: °F
CFPM Verification (name, ID#, expiration date):
CHRIS ROWE
19066363
02/13/2025 		BRITTNEY TRAVIS
19066240
02/13/2025 		ANASTASIO ROJOAS
19066362
02/13/2025 		FORTINA ZAVALETA
19066142
02/13/2025

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
jambalaya/kitchen prep cooler 39.00°F macaroni/kitchen prep cooler 39.00°F tomatoes/kitchen main prep cooler 41.00°F
shredded cheese/kitchen main prep cooler 42.00°F bacon/flat top drawer cooler 42.00°F aus jus/kitchen hot hold 169.00°F
milk/wait staff reach in cooler 41.00°F orange juice/1st walk in cooler 40.00°F fries/reach in freezer 0.00°F

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
10 PF 5-205.11 (B): (B) A HANDWASHING SINK may not be used for purposes other than handwashing.
Observed a spoon in the hand sink in the kitchen. Provide for all hand sinks to only be used for hand washing. COS
39 C 3-305.11 (A) (B) (C): (A) Except as specified in ¶¶ (B) and (C) of this section, FOOD shall be protected from contamination by storing the FOOD: (1) In a clean, dry location; (2) Where it is not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor. (B) FOOD in packages and working containers may be stored less than 15 cm (6 inches) above the floor on case lot handling EQUIPMENT as specified under § 4-204.122. (C) Pressurized BEVERAGE containers, cased FOOD in waterproof containers such as bottles or cans, and milk containers in plastic crates may be stored on a floor that is clean and not exposed to floor moisture.
Observed a box of tomatoes on the floor in the second walk-in cooler. Provide for all food items to be stored up and off of the floor and maintained by next routine inspection.
43 C 3-304.12 (A): During pauses in FOOD preparation or dispensing, FOOD preparation and dispensing UTENSILS shall be stored: (A) Except as specified under (B) of this section, in the FOOD with their handles above the top of the FOOD and the container.
Observed a lot of the prep table foods to have cups and bowls being used as scoops in the kitchen. A proper has a handle that does not come into contact with the food items. Provide and maintain by next routine inspection. Repeat
45 C 4-903.11( A)(1)(2)(3): (A) Except as specified in ¶ (D) of this section, cleaned EQUIPMENT and UTENSILS, laundered LINENS, and SINGLE-SERVICE and SINGLE-USE ARTICLES shall be stored: (1) In a clean, dry location; (2) Where they are not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor.
Observed the plastic cups between the prep coolers in the kitchen to be stored with the food contact surface up. Store inverted and maintain by next routine inspection.
47 C 4-101.19: NonFOOD-CONTACT SURFACES of EQUIPMENT that are exposed to splash, spillage, or other FOOD soiling or that require frequent cleaning shall be constructed of a CORROSION-RESISTANT, nonabsorbent, and SMOOTH material.
Observed heavily soiled card board on top of the white reach in freezer by the fryers. Cardboard is not a proper surface material to be used in the kitchen. Remove and maintain by next routine inspection.
49 C 4-601.11(C): (C) NonFOOD-CONTACT SURFACES of EQUIPMENT shall be kept free of an accumulation of dust, dirt, FOOD residue, and other debris.
Observed the following areas in need of cleaning:
Top of the white reach in freezer to be in need of cleaning.
Inside of the prep cooler by the kitchen hand sink.

Clean and maintain by next routine inspection. Repeat
Inspection Comments   FACILITY WAS COVERED WITH CFPM LICENSES FOR THIS INSPECTION.

OBSERVED THIS FACILITY USING LATEX GLOVES.
(410 ILCS 180/10)
SEC. 10. USE OF LATEX GLOVES PROHIBITED.
(A) ON AND AFTER JANUARY 1, 2023, A FOOD SERVICE ESTABLISHMENT MAY NOT PERMIT EMPLOYEES TO USE LATEX GLOVES IN THE PREPARATION AND HANDLING OF FOOD. IF LATEX GLOVES MUST BE USED IN THE PREPARATION OF FOOD DUE TO A CRISIS THAT INTERRUPTS A FOOD SERVICE ESTABLISHMENT'S ABILITY TO SOURCE NONLATEX GLOVES, A SIGN SHALL BE PROMINENTLY PLACED AT THE POINT OF ORDER OR POINT OF PURCHASE CLEARLY NOTIFYING THE PUBLIC OF THE TEMPORARY CHANGE. TO ENCOURAGE COMPLIANCE WITH THIS SUBSECTION, THE DEPARTMENT SHALL SEND A NOTICE OF WARNING TO A FOOD SERVICE ESTABLISHMENT FOR ITS FIRST VIOLATION OF THIS SUBSECTION.
HACCP Topic: PROPER HOT HOLDING TEMPS FOR COOKED FOOD ITEMS
 

Person In Charge

  TOM SPELLMAN 		 

Date:

  02/25/2025
 

Inspector

  Angela Colon 		 

Follow-up:  Yes   No   Follow-up Date: